Product ID:SILICONE ALKYD COPOLYMER ENAMEL, 15109 LT BLUE
MSDS Date:03/01/1997
FSC:8010
NIIN:00N091615
Status Code:A
MSDS Number: CJMNQ

Emergency Phone: 206-244-8844

Info Phone: 800-727-9694

Cage: 6F266

Telephone: 206-244-8844

Cage: 6F266

LIGROINE; (MINERAL SPIRITS 350)

CAS: 8032-32-4

RTECS: OI6180000

OSHA PEL 100 PPM

ACGIH TLV: 1370 MG/M3;300 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: THIS MATERIAL MAY CAUSE
IRRITATION, SENSITIZATION, OR DEFATTING OF SKIN UPON PROLONGED OR
REPEATED CONTACT. INHALATION: EXCESSIVE EXPOSURE TO VAPORS OR SPAY
MIST MAY RESULT IN HEADACHE, DIZZINE SS, NAUSEA AND LOSS OF
CONSCIOUSNESS. SOME REPORTS HAVE ASSOCIATED REPEATED & PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN &
NERVOUS SYSTEM DAMAGE. EYES: THIS MATERIAL MAY BE A N EYE IRRITANT.
Explanation of Carcinogenicity:THIS PRODUCT CONTAINS NO KNOWN
CARCINOGENS IN REPORTABLE QUANTITIES AS DEFINED BY ACGIH, OSHA,
NTP, IARC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE, WHEN USED IN ACCORDANCE WITH
SAFE HANDLING INSTRUCTIONS. (SEE SECTION 7).

First Aid:SKIN: PROMPTLY WASH WITH SOAP AND WATER. REMOVE AND WASH ANY
CONTAMINATED CLOTHING BEFORE REUSE. EYES: FLUSH WITH LARGE
QUANTITIES OF WATER FOR AT LEAST 15 MINUTES AND SEEK MEDICAL
ATTENTION. INGESTIO N: IF INGESTED DO NOT INDUCE VOMITING; KEEP
PERSON WARM AND QUIET AND GET MEDICAL ATTENTION. ASPIRATION OF
MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE
FATAL. INHALATION: REMOVE VIC TIM TO FRESH AIR IMMEDIATELY. IF
RESPIRATORY SYMPTOMS DEVELOP. SEEK MEDICAL ATTENTION AT ONCE.

Flash Point Method:TCC
Flash Point:=41.7C, 107.F
Lower Limits:0.7%
Upper Limits:6.0%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . USE THE ABOVE OR ANY CLASS B EXTINGUISHING AGENT.
WATER MAY BE UNSUITABLE AS AN EXTINGUISHING MEDIUM, BUT HELPFUL IN
KEEPING ADJACENT CONT AINERS COOL. EVACUATE AREA OF UNPROTECTED
PERSONNEL. WEAR PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM AN EXPLOSIVE MIXTURE IN
AIR AND MAY BE IGNITED BY SPARKS, PILOT LIGHTS, ETC. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT. FLAMMABILITY
CLASSIFICATION: OSHA: COMBUSTIBLE CLASS:3.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. ABSORB SPILL WITH AN ABSORBENT MATERIAL SUCH AS SAWDUST,
VERMICULITE OR SAND AND PLACE MATERIAL INTO A CLOSED CONTAINER. IF
LARGE SPILL; DIKE AREA TO PR EVENT THIS MATERIAL FROM ENTERING
WATERSYSTEMS OR SEWERS. WEAR PROTECTIVE EQUIPMENT DURING CLEANUP.

Handling and Storage Precautions:AVOID PROLONGED OR REPEATED INHALATION
OF HEATED VAPORS OR SPRAY MIST. KEEP AWAY FROM HEAT OR OPEN FLAMES.
THIS MATERIAL MAY CAUSE SENSITIZATION. DO NOT GET IN EYES. ON SKIN
OR CLOTHING. DO NOT ALLOW CONTAMINATED CLOTHING TO CONTACT SKIN.
DO NOT WELD ON FULL OR EMPTY CONTAINERS.
Other Precautions:KEEP CONTAINERS CLOSED WHEN NOT IN USE AND PROPERLY
LABELED. KEEP OUT OF THE REACH OF CHILDREN.

Respiratory Protection:A NIOSH APPROVED CANISTER-TYPE RESPIRATOR MUST
BE WORN TO PREVENT THE INHALATION OF VAPORS OR SPRAY MIST WHEN THE
TLV OR PEL IS EXCEEDED.
Ventilation:GENERAL VENT IS REQUIRED DURING NORMAL USE. LOCAL VENT MAY
BE REQUIRED DURING CERTAIN OPERATIONS TO KEEP EXPOS LEVEL BELOW
LIMITS IN SECTION 2 OF THIS MSDS.
Protective Gloves:CHEMICAL RESISTANT NITRILE, NEOPRENE OR RUBBER
GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES AND FULL LENGTH
FACESHIELD .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR PROTECTIVE CLOTHING TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
WASTE DISP METHOD: IF DISCARDED, THIS MATL AND CONTAINERS SHOULD BE
TREATED AS HAZARDOUS WASTE BASED ON THE CHARACT OF IGNITABILITY AS
DEFINED UNDER FEDERAL RCRA REGULATIONS (40 CFR 261). DISPOSAL O F
THIS MATERIAL OR ITS CONTAINERS REQUIRES COMPLIANCE WITH APPLICABLE
LABELING, PACKAGING AND RECORDKEEPING STANDARDS.

Boiling Pt:>152.8C, 307.F
B.P. Text:307-387F
Vapor Pres:2.6 MMHG @ 20C
Vapor Density:HVR/AIR
Spec Gravity:1.21
VOC Pounds/Gallon:340
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NIL
Appearance and Odor:WHITE LIQUID (OR COLOR OF TINT), MILD ODOR.
Percent Volatiles by Volume:45

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDANTS, ACIDS, BASES AND EPOXY HARDENERS
UNDER UNCONTROLLED CONDITIONS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME. IF PRODUCT
CONTAINS ALUMINUM, MOISTURE IN CLOSED CONTAINERS WILL GENERATE
HYDROGEN GAS.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD CARBON
MONOXIDE AND TOXIC VAPORS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL AGENCIES. GROUND HANDLING EQUIPMENT TO PREVENT SPARKS. FOR
FURTHER INFORMATION: CONTACT YOUR STATE OR LOCAL WASTE AGENCY OR
THE UNITED STATES ENVIRO NMENTAL PROTECTION AGENCY'S RCRA
HOTLINE(1-800-424-9346 OR 1-202-382-3000). (SUP DAT)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT: COMBUSTIBLE. UN NUMBER: 1263.

SARA Title III Information:PURSUANT TO TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) AND 40 CFR PART
372, THIS PRODUCT CONTAINS OR MAY CONTAIN A TOXIC CHEMICAL IN A
QUANTITY SUBJECT TO REPORTING R EQUIREMENTS UNDER SECTION 313.
THIS MATL HAS BEEN CATEGORIZED AS HAVING THE FOLLOWING HAZ(S) AS
DEFINED BY SARA TITLE III REG(S) (40 CFR 370): ACUTE, FIRE.